Negative Ion Generator（英文版）

天狼晓月

Negative Ion Generator
by John Iovine
Make the very air you breathe healthier with an easy-to-build high voltage project"

Air is the most important ingredient to our survival. Think about it; you may survive a few days without water, a little longer without food, but, deprived of air, your survival time can be measured in minutes.
The quality of the air surrounding many cities has become so poor that many local news stations provided an air-quality report along with the weather forecast. Air pollution is so commonplace now that words have been created to describe it. The word "smog" for example, a contraction of the words "smoke" and "fog". As if smog wasn't enough, today there are new pollution concerns, not the least of which are the increasing CO2 level, the green-house effect, the depletion of the ozone layer, and acid rain.

Research:
Long before there was any talk or concern about air pollution and such, some scientists and experimenters noticed that the ionization of even clean air can improve its quality. Clean air (principally composed of 78% nitrogen and 21% oxygen) is typically full of positive and negative ions in approximately a 5-to-4 ratio. What researchers found was that when this ratio changes one way or the other it has an effect on biological systems.
This idea was popularized by Fred Soyka who, in the 1970's, wrote a book titled "The Ion Effect". Mr Soyka studied natural occurrences of negative and positive ionized air. His findings and inquiries demonstrated that negatively ionized air had substantial health benefits.

To summarize a few points from his book, negative ions help elevate mood, enhance physical performance and training, and sterilize harmful airborne bacteria. An abundance of positive ions on the other hand can be held responsible for a number of low grade medical problems, such as fatigue, headache, and anxiety.
There are detractors to this point of view. So before I started to design a negative-ion generator, I did some research to find out if it would be worthwhile. I surveyed approximately 100 world-wide scientific reports on the effect of negative ions from 1973 through the present (1992). I can report that out of my survey approximately 80% of the citing's note the beneficial effect of negative ions. Greater than 19% of the reports described no effect, an a few (less than 1%) detailed some detrimental effect. Since the preponderance of the evidence supports the beneficial effect of negative ions, I felt that building and ion generator was a worthwhile project. A summary of some of the beneficial effects reported by some researches are listed in the boxed text entitled "The Positive Effects of Negative Ions". It is by no means and exhaustive list, it's just a sampling of the scientific benefits noted. But if this is the case it would be to our benefit to improve the quality of air that we breathe with a negative ion generator.
Despite the numerous scientific reports supporting the health benefits of ionized air, no manufacturer of negative-ion generators can make any health-benefit claims without running afoul of the FDA. For that reason I also will make no such claims. Instead, the research papers supporting this article are listed in the text entitled "Bibliography" so you can do the research on your own an make your own decision.


The Ion Generator:
The design of the Negative-Ion Generator is fairly straightforward (see Fig. 1). The circuit is a high voltage generator. It contains a standard 555 timer that's used to generate square-wave pulses. The pulses are applied to the base of the TIP120 NPN Darlington transistor. The Darlington provides sufficient current to the base of the 2N3055 power transistor to turn it on. Each time that happens, current flows through the high voltage auto-transformer, T2. The high voltage lead of the transformer is connected to a 10 kilovolt high voltage diode. Notice the polarity of the diode. It is biased to place a negative charge on C3 and C4, leaving the discharge point negatively charged. The voltage at the discharge point negatively charges the air forced past it by the fan.
The author's prototype was built on sections of perfboard using point-to-point wiring. It is a suitable method that you can use in your won ion generator provided you follow some precautions: Make sure you place C3, C4, D1, and the discharge point (which we'll describe momentarily) on a piece of perf board all their own. The junctions between those components should be at least a centimeter (about 1/2-inch) apart. Both this little high voltage board and the autotransformer should also be kept at least 1 centimeter away from the perfboard containing the other components, the fan, and the power transformer.
In passing, if you chose not to buy D1 from the supplier (1992) mentioned in the Parts List, an exact replacement may be difficult to locate. However, even though it has a lower current rating, an ECG518 or NTE518 should work fine, although this substitution has not been tried.
The discharge point should be "pointy" to enhance the ionization of the air. You can use a sewing needle, for example. An alternate discharge point can be fashioned from a small piece of No. 22 stranded wire. Strip off about 1/2-inch from one end of the wire and separate the fine copper strands so that they are more of less evenly dispersed. When the wire is connected to the high negative voltage, the end of each strand will behave as a discharge point.
Any screen or covering on the fan-outlet hole should be non-metallic or plastic in nature. Using a metal screen would severely cut the efficiency of the generator because the negative ions that come into contact with the metal screen would be neutralized.
When testing the circuit, if you see any arcing or discharge from the high voltage transformer or high voltage capacitors, cut the power immediately. Let the project sit for awhile to let the capacitors discharge, and, without touching the project if possible, coat the faulty are with a little "No Arc" spray (available from Radio Shack or Tandy). Allow the material to dry before testing the unit again.
(Tony's comment: The ECG518 and NTE518 are still available, the added bonus is that the ECG/NTE518 supplies 25mA instead of 10mA by the IMD5210).
Parts List:   R1 = 15K, 1/4W, 5%   R2 = 1K, 1/4W, 5%   R3 = 2.2K, 1/4 W, 5%   R4 = 470, 1/4 W, 5%            C1 = 1000uF/25V, electrolytic   C2 = 0.047uF, polyester-filmC3,C4 = 0.002uF, 6000WVDC, ceramic disc   U1 = 555 timer, 8-pin IC (no CMOS)   Q1 = TIP120 or NTE261, NPN, Darlington transistor   Q2 = 2N3055, NPN, power transistor   D1 = 10,000 Volt, 10mA, SI rectifier diode (see text)  BR1 = 4A, 50-PIV bridge rectifierAdditional Parts and Materials:  T1 = 12 volt 1.2A, power transformer  T2 = 12 volt to 8 kilo volt autotransformerFAN1 = 12 volt DC fan.Enclosure, line cord, switch, TO-3 socket/heat sink, perfboard, wire, solder, hardware, etc.The original supplier was "Images Company" , P.O. box 14072 Staten Island, NY 10314-024; Tel. 718/698-8305): D1 ($1.50), C3 and C4 ($1.50 each), and T2 (17.95).  Include an additional $2.50 for shipping and handling.(Tony's note for the above: This is the original information as it appeared in PopularElectronics at the time in 1992.  The company may no longer exist or if it does,may no longer have the components, or charge different prices, etc, etc.)

The Positive Effects of Negative Ions:

• Learning enhancement in normal and learning-disabled children. The task used to test the children was a dichotic listening test.
• Negative ions can be used to decrease amounts of radon in a building atmosphere.
• In one animal study, 1279 calves were broken into two groups, one of 649 head and the other of 630 head, negative air ionization was used to test for a prophylactic effectiveness against respiratory diseases. The results were remarkable: In the treated group (649 head) 45 calves became sick and 3 died. In the control group (630 head) 621 became sick and 33 died.
• A 40-50% reduction of microbial air pollution in dental clinics.
• A test using college students showed improved performance on a visual vigilance task.
• In 1983 it was reported that chickens raised in a negatively ionized atmosphere showed improved anabolic processes. The chickens raised in negatively ionized air had an overall greater weight than a control group fed the same quality and quantity of feed. The meat of the treated group had higher protein and essential amino-acid content. In addition, higher concentration of vitamins E and A were found in their livers.

Bibliography:
"Negative Air Ion Effects on Learning Disabled and Normal Achieving Children", L.L. Morton and J.R. Kershner, University of Windsor, Faculty of Education, Ontario, Canada, 1990.
"Effect of Negative Ion Generators in a Sick Building", M.J. Finnegan, C.A. Pickering, F.S. Gill 1st, Aston, and D. Froese, Department of Thoracic Medicine, Wythenshawe Hospital, Manchester, England, 1987.
"Aeroionization in Prophylaxis & Treatment of Respiratory Disease in Calves", T.I. Sologub, N.F. Borzenko, V.P. Zernlyanskiy, and K.F. Plakhotnyy, Russia, 1984.
"Effect of Ionization on Microbial Air Pollution in the Dental Clinic", J. Gabby, O. Bergerson, N. Levi, S. Brenner, and I. Eli, Research Institute for Environment Health, Sackler School of Medicine, Tel Aviv, Israel, 1990.
"Effects of Ionized Air on the PErformance of a Vigilance Task", G.C. Brown and R.E. Kirk, Systems Research Laboratories, Inc., Brooks Air Force Base, Texas, USA, 1987.
"Negative Ions", J.E. Wright, Muscle & Fitness Magazine, January 1991.
"Effect of Artificial Air Ionization on Broilers", P. Stoianov, G. Petkov, and B.D. Baikov, Vet Med Nauki, Bulgaria, 1983.